Replaced Failed Compressor
Replaced failed compressor. Recovered refrigerant and replaced filter driers, compressor and contactor and confirmed to be functioning properly on 5/15/24 in Fort Worth Texas. Near 701 Galveston Ave Fort Worth, Texas 76104 Check out the Areas We Serve and jobs we are doing by clicking https://dallas.arlington.prorefrigerationone.com/areas-we-serve/ [spacer]
Phase Monitor was Not Working
Phase monitor was not working and seemed to be holding the compressor off. I acquired a new phase monitor and installed it. I started the system up and found a breaker trip on stage to call. I back tracked the failure all the way to the recently replaced stage 2 compressor. This compressor is under […]
Condenser was Off in High Limit
Condenser was off in high limit. Reset condenser and compressor started. Measured all parameters and all are within specs. Condenser fan is cycling off/on. Sight glass is full. Returning glycol at 67 degrees. Supply glycol at 43 degrees. Fan running and clean wheel. Cinder coils clean. Noted storms recently make have induced a power surge […]
Found one Leaking Access Valve
Found one leaking access valve so replaced the core and both plastic caps with brass on 3/18/24 in Fort Worth Texas. Near NW Hwy 287, Fort Worth, Texas 76104 Check out the Areas We Serve and jobs we are doing by clicking https://dallas.arlington.prorefrigerationone.com/areas-we-serve/ [spacer]
Replaced Compressor on Glycol Chiller
Replaced compressor on glycol chiller. replace. contactor, replace refrigerant and drier, and install new compressor protector on 3/6/24 in Fort Worth Texas. Near Galveston Ave Fort Worth, Texas 76104 Check out the Areas We Serve and jobs we are doing by clicking https://dallas.arlington.prorefrigerationone.com/areas-we-serve/ [spacer]
Unit Had a Door That Had Fallen Off
Unit had a door that had fallen off. I bent the bottom hinge back in shape and reinstalled the door. Unit turned on and cooled fine on 2/23/24 in Arlington Texas. Near Valcasi Dr Arlington, Texas 76001 Check out the Areas We Serve and jobs we are doing by clicking https://dallas.arlington.prorefrigerationone.com/areas-we-serve/ [spacer]
Disconnect Power and Cut Insulation and Piping at Both Ends
Disconnect power and cut insulation and piping at both ends. Using existing pipe along with necessary new pipe reroute through roof and out of the concrete wall using PVC sleeve above the outdoor walk in. Pull vacuum on both systems, seal the holes in the concrete with foam and fire-retardant sealant. Restore power and open […]
Joint Leaking by the Evaporator
Joint leaking by the evaporator. Rewelded joint and checked, No leaks at this time, and found no further problems at this time on 2/13/24 in Fort Worth Texas. Near N Fwy Fort Worth, Texas 76177 Check out the Areas We Serve and jobs we are doing by clicking https://dallas.arlington.prorefrigerationone.com/areas-we-serve/ [spacer]
Removed the Receiver Tank and Installed New One
Removed the receiver tank and installed new one. Replaced the filter drier. Checked again for leaks and found none. Verified proper operation and Temp on 2/7/24 in Arlington Texas. Near W Pioneer Pkwy Arlington, Texas 76013 Check out the Areas We Serve and jobs we are doing by clicking https://dallas.arlington.prorefrigerationone.com/areas-we-serve/ [spacer]
Encapsulated Low Pressure Control was Bad
Encapsulated low pressure control was bad. Picked up new pressure control and to installed. verified proper operation on 2/6/24 in Arlington Texas. Near E Lamar Blvd Arlington, Texas 76006 Check out the Areas We Serve and jobs we are doing by clicking https://dallas.arlington.prorefrigerationone.com/areas-we-serve/ [spacer]